Excellent vehicle ignition coil provider: Gasoline vehicles are usually powered by a simple 12-volt DC battery. This is enough voltage to engage a starter motor and get the engine turning, but it’s not enough for actual combustion. (A spark plug needs around 40,000 volts for combustion.) That’s where the ignition coil comes in. It contains a step-up transformer (also known as a coil pack) to convert that tiny current into quick bursts of several thousand volts at a time. This electricity is then sent to each spark plug in perfect time with the cylinder’s combustion cycle, igniting fuel vapor with oxygen and producing power. Diesel engines notably lack ignition coils because they ignite their fuel using heat and pressure alone. Read even more information at https://www.hj-auto.com/ignition-coil.
Ignition coils typically have a long life of operation — over 100,000 miles. However, they can malfunction eventually, causing that dreaded misfire. This issue will probably start out slowly while being hardly noticeable but will become more problematic over time. When a misfire occurs, even for a few seconds, your engine computer management will likely detect the issue and generate a trouble code. At which point the check engine light comes on. With a diagnostic scanner at a garage or auto parts store, you can then see which cylinder is misfiring and proceed from there. Another sign of a misfire can be a rough engine idle. In extreme cases, the vehicle may feel like it’s surging at a high RPM or like it may stall at low speeds.
The car coil itself is a transformer, which is like a transformer in a household appliance. When the voltage changes within a specified range, the transformer will not be burned. Usually, the burning of the transformer occurs when the transformer is overloaded. When solving this problem, we must try to find out the cause of the excessive load or the aging of the components. If there is no fire or weak sparks that suddenly occur during driving, an infrared thermometer or hand touch can be used to determine whether the car coil or the ignition module has an internal short circuit or open circuit fault. When the fault is judged, it can also be restarted. Total of 8 R&D personnel in our factory, Haiyan wholesale ignition coil suppliers have more than 15 years of working experience.
The primary winding of an ignition coil will typically contain 150 to 300 turns of wire; the secondary winding will typically contain 15,000 to 30,000 turns of wire, or around 100 times more than the primary winding. The magnetic field is initially created when the vehicle’s electrical system applies approximately 12 volts to the ignition coil’s primary winding. When a spark is required at a spark plug, the ignition system will switch off the current flow to the primary winding, which will cause the magnetic field to collapse. The collapsing magnetic field will induce a voltage into the primary winding in the region of 200 volts; but the voltage induced into the secondary winding will be approximately 100 times greater, around 20,000 volts.
The Kettering ignition system became virtually the only type of ignition system for mass-produced petrol cars, and stayed that way until electronically switched and controlled ignition systems started to replace mechanical ignition systems during the 1970s and 1980s. The basic principle of an ignition coil: To produce the required high voltages, ignition coils make use of the relationships that exist between electricity and magnetism. When an electric current flows through an electrical conductor such as a coil of wire, it creates a magnetic field around the coil (Figure 2). The magnetic field (or, more precisely, magnetic flux) is effectively a store of energy, which can then be converted back into electricity.
The engine coil is the main product of Haiyan ignition coil wholesale supplier. Haiyan insists on the use of high-quality materials and advanced technology to manufacture car engine coil. Besides, we strictly monitor and control the quality and cost of each auto ignition coil production process. All this guarantees the auto ignition coil to have high quality and favorable price. According to the function, the auto repair tool cabinet can be divided into mobile tool cabinets and wall tool cabinets. Wheels are installed under the mobile tool cabinet for convenient movement. Haiyan wholesale metal tool cabinet is a shelf like a closet. Find even more information at https://www.hj-auto.com/.
Haiyan car ignition coil suppliers have 200 workers, around 170 work over 4 years, with an independent long-term workflow and productivity, have one department including 30 products technology development and research. Our automotive ignition coil manufacturers cover over 14000 square meters, have been awarded city contracts and keeping promises to units, also we certify ISO9001, and TS16949 for a quality system, truly achieving the quality first, reputation first quality service for our customers at home and abroad. Kindly welcome domestic and overseas patrons to come and guide.